Please Note: Because of the nature of the products on this page, it's often best to get advice before you order.
for certain difficult waters, whole house reverse osmosis is sometimes not only the best solution, it is virtually the only solution. the most common application for large, point-of-entry reverse osmosis is water with high salt content. reverse osmosis effectively removes sodium, chloride, fluoride and other difficult-to-treat contaminants.
Reverse osmosis has unique properties and solves problems that are often impossible for conventional filters. For a good list of percentage rejection figures for various contaminants, go here.五分快三精准在线人工计划 Keep in mind that the list gives expected figures for small drinking water units, and the high pressure units described here usually perform a few percentage points better. Keep in mind, too, that carbon filtration can be used in conjunction with whole house reverse osmosis units and the carbon/reverse osmosis combination adds virtually all chemical contaminants to the list of items reduced.
五分快三精准在线人工计划 typically, a whole house system would include the following:
Pre-treatment for the RO unit, as needed. The reverse osmosis unit itself usually has only a small sediment prefilter. For some situations, where the water is good except for a high amount of sodium, for example, no additional pretreatment is needed. For most well water, however, the RO unit will need to be protected from sediment, iron, manganese, or hardness. This may require the use of a sediment filter, a water softener, an iron filter, or a sequestering additive (such a polyphosphate injection) as a pretreatment to protect the RO unit. RO units used on city water (for water vending or final rinse car wash applications, for example) will require carbon or carbon/KDF prefiltration to protect the RO unit from chlorine or chloramines.
A reverse osmosis unit五分快三精准在线人工计划 to produce as much water as the household might need for a day. For example, a 600-gallon per day unit would be typical. A 600-gallon unit would produce usable water at the rate of about 25 gallons per hour. Since 25 gallons per hour is not enough to supply the demands of normal household functions such as laundry and showers, a storage system is needed so that ample water will be on hand when needed.
keep in mind that the 600 gallon example is theoretical. a 600 gallon per day unit may produce much more or much less than 600 gallons per day. ro production depends on such variables as tds (total dissolved solids) of the water treated and temperature of the water. ro units produce much faster when treating warm rather than cold water.
Storage tank and accessories.五分快三精准在线人工计划 An atmospheric (non-pressurized) storage tank large enough to provide ample water for daily activities. The reverse osmosis unit refills the tank as water is taken from it. The water is stored at atmospheric pressure and must, therefore, be re-pressurized for use. The tank needs a few accessories, like bulkhead fittings to allow entry and exit of water, a float switch to tell the RO unit when more water is needed, and miscellaneous piping.
Repressurization system. This system can consist simply of a pump that comes on automatically when water is needed and supplies pressurized water to the home, or it can include a smaller bladder tank that is filled to house pressure by a pump to give a more even supply of water when the demand arises. With most repressurization pumps, the bladder tank will be essential to avoid erratic pump performance. Some very high quality pumps are designed to operate without the additional bladder tank.
Post-RO Treatment. Since reverse osmosis treatment lowers the pH of water, most users will want a post treatment system to raise the pH to neutral or near neutral. This is most commonly done with a simple calcite tank. The calcite tank can be placed before the atmospheric storage tank or as the last item in the treatment system, before the water enters the home. You'll need a larger calcite tank if you place it after the storage tank because it will have to handle water at a much higher flow rate.
五分快三精准在线人工计划 this page presents only one of many large reverse osmosis units available through pure water products from watts, one of the nation's premier makers of large reverse osmosis units.
we like the r-12 because of its simplicity and ease of installation and operation. it is ideal for most residential applications.
the r-12 is basic ro at its best: tough and reliable, with standard-sized components, designed for years of reliable service. you will appreciate the use of standard-sized components when it comes time to replace a part. for example, the r-12 uses an easy to find 2.5" x 40" membrane. when you replace it, you will have lots of brand and price options that aren't available with proprietary units for which the manufacturer requires you to buy his brand at his price. pumps and motors are also standard industry items that you can purchase from a variety of sources.
五分快三精准在线人工计划 the r-12 is perfectly sized for most home users. we offer it in two production sizes — 600 and 1200 gallons per day. the units are identical, except that the 1200 gallon unit has two membranes and the 600 has one.
五分快三精准在线人工计划 (600 & 1200 gallon-per-day units have the same measurements.)
五分快三精准在线人工计划 both inlet and reject water connections are with 3/8" plastic tubing.
the unit runs on standard 120 volt/60 hz house current. 8 amps.
五分快三精准在线人工计划 minimum feed water requirement is 2.4 gallons-per-minute at 10 psig.
五分快三精准在线人工计划 maximum drain capacity needed is 2.4 gallons-per-minute.
五分快三精准在线人工计划 the units use either one or two 2.5" x 40" reverse osmosis membranes and recovery rate is up to 50%. it has an adjustable recycle system to reuse some of the reject water.
Go here for help in sizing a whole house R.O. system.
五分快三精准在线人工计划 watts “whole house option” for r-12 ro units includes virtually everything you need for a complete installation, including a storage tank with bulkhead fittings, pre-wired float switch, and grundfos repressurization pump. the top-quality grundfos pump offers the great advantage that it can be installed without an additional pressure tank.
this system works for both 600 and 1200 gallon per day units.
五分快三精准在线人工计划 if you're running your ro unit on relatively clean water, this feature is probably not needed. however, if the tds of the water you're treating is high, this feature will be more than worth the expense.
the purpose of the auto-flush feature is to flush the membrane upon startup and periodically thereafter. it can make a remarkable difference in performance and membrane longevity if your dissolved solids level is high. it can add greatly to the lifespan of membranes, and it can significantly improve the unit's tds rejection performance.
五分快三精准在线人工计划 r-12 units are designed for wall mounting. if you prefer a free-standing installation, however, order this stainless steel leg kit. works for 600 or 1200 gallon models.
Gives separate TDS readings of both incoming and product water. Includes all mounting hardware, fittings, and instructions. Can be ordered as an option to either the 1200 gallon or 600 gallon Watts R12 unit. Batteries included.
Note: A TDS tester is an absolutely necessary tool for maintaining a reverse osmosis unit. However, you can get by with a less expensive, hand-held tester. (See our "RO Parts" page五分快三精准在线人工计划 for hand-held testers.)
五分快三精准在线人工计划 here are some product suggestions for pre-treatment. this is not intended as a complete discussion but as a reference to pages on our site where you can find more information and purchase pre-treatment products. we welcome calls and emails requesting more information on these issues.
Iron can be removed by Filox or Birm filters. You may need to pre-treat for the filter an oxidizer such as aeration or chlorination. Iron in small amounts can also be reduced with a water softener五分快三精准在线人工计划. For RO pre-treatment, twin softeners are preferred, because they can provide an uninterrupted flow of treated water. (Please call (940) 382-3814 for information about twin softeners.)
Hardness is best treated by a water softener, but alternatives like poly-phosphate injection and alternative scale prevention systems are sometimes used. As stated above, twin softeners work best with RO units because an uninterrupted supply of softened water is required.
The standard way to increase pH after a reverse osmosis unit is with a backwashing calcite filter. For smaller, non-backwashing calcite tanks, please call (940) 382-3814.
五分快三精准在线人工计划 the “whole house option” for large ro units is a product that's long overdue. it takes the guesswork out of planning a whole house installation. except for incidentals specific to your application, which are hardware store items, it has everything you need to store the water made by the ro unit and send it to your home.
五分快三精准在线人工计划 the whole house option comes with an atmospheric storage tank. three tank sizes are available. 300 gallons is an ideal size for most residential whole house installations. the tank is pre-fitted with three bulkhead fittings, and the ro shutoff float valve is preinstalled, so that you just have to plug the ro unit into the electrical outlet on the float switch and plug the float switch into a standard 115 volt ac outlet and you're ready to go.
五分快三精准在线人工计划 the delivery pump is the superior, self-priming grundfos mq3-45 110-120 volt 1 hp pump. the complete-in-itself mq3 takes all the worry out of pump setup. you won't need a separate pressure tank, which more basic repressurization pumps require, and you won't need a pressure switch, additional electrical connections or fittings, or any of the other accessory items pump installation usually requires. very easy to set up and operate, the mq3 features a user-friendly control panel that has everything you need to get the pump up and running quickly. the pump has its own small built-in pressure tank to assure smooth, instant delivery of water upon demand. the check valve is also built into the pump. the pump is protected from an empty storage tank by a built-in dry run protection feature which automatically shuts off the pump if no water is available and even has an automatic restart feature to restore the pump to service when water is available.
五分快三精准在线人工计划 you won't find a better, more durable, or easier to operate delivery pump.
(whole house & well units)